ATV | Calendar | ATV/UTV Reviews | ATV/UTV News | ATV/UTV Product Reviews | ATV/UTV Racing | ATV/UTV Trails | ATV/UTV Videos Social Community Forums is a social community site based on the needs of ATV/UTV fans alike.
It is currently Mon Dec 10, 2018 5:46 am

All times are UTC - 5 hours

Post new topic Reply to topic  [ 2 posts ] 
Author Message
PostPosted: Thu Feb 25, 2010 11:13 am 
Still on the Trailer Member

Joined: Thu Feb 25, 2010 8:24 am
Posts: 2
The machine starts nd idles fine but when driving can't go over 1/4 to 1/2 throttle it will cut in and out. I took carb off cleaned it good ,replaced the plug , put back together and same thingbut not as bad. the problem occurs in all ranges and gears even in neutral. Thanks for any help



PostPosted: Sun Feb 28, 2010 11:21 pm 
Trail Riding Member

Joined: Tue Sep 16, 2008 6:41 pm
Posts: 59
The old 300's were very tempermental machines.first make sure the intake assembly is installed or else it will not run right.sometimes you even have to have the seat on for it to run right because it limits the amount of air going in the intake.What did the inside of your carb look like?make sure the little silver guide is under your main jet,its the thing the air needle goes up and down inside of. this piece is very much compression do you have? if your compression is low the the motor will not be able to pull the amount of fuel in that is necessary to run at half throttle.I was glad to see arctic cat stop using this suzuki mtor because it truly is a pain in the arse

Display posts from previous:  Sort by  

Post new topic Reply to topic  [ 2 posts ] 

All times are UTC - 5 hours

Who is online

Users browsing this forum: No registered users

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum

Search for:
Jump to:  
Powered by phpBB® Forum Software © phpBB Group